MapleAcres

Into the woods by 11:15 AM to get syrup into the finishing pan.  Syrup was finished and filtered by 1:00 PM.  Done with bottling and cleanup by 1:50 PM.

Then headed out to collect.  Tonight the forecast is 18.  Any sap will freeze.  Get it while its liquid.  We hoped for a tank full, 225 gal, but ended up with 165 gal.  A few running well, but many are dry.   The taps are out over a month so dry taps are expected.  But with a low of 23 the other night and sunny yesterday we should have more sap.  Since we didn’t its a signal we are coming to the end of the season.   We could be surprised because we get the freeze/thaw pattern this coming week.

Planning to begin cooking early tomorrow.   We have plans for Easter dinner at Noon and want to be done cooking by 11:00 AM.  We should be able to meet that if we get into the woods by 6:00 AM.

No snow last night.  Lite rain started by 8:00 AM this morning.  Cloudy and windy.  Did reach low 40s before the wind shifted to the North and temperature dropped.

Back to the farmhouse by 6:15 PM.

Into the woods by 7:00 AM.  A little later then past days because we knew we would finish earlier with only 200 gallons to cook.

Had to thaw out frozen pipes on the storage tank.  We use an electric heat gun originally intended to strip paint.  We used to use a propane torch.  This is much nicer and easier to work with.  After 3-5 minutes the gurgle starts in the tank as sap pushes out air.

R/O from 8:05 AM to 10:35 AM.  Three batches into milk cans.  We again have two full cans of syrup to finish and bottle.

24 overnight dropping to 20 around dawn.  Sunny most of the day until after 5:00 PM.  Temperature 42.  Trees dripped some, but not enough to collect.   Tonight low of 30 with snow/rain after midnight.  Possibly an inch accumulation.  Tomorrow windy, cloudy and 40.

Back to the farmhouse by 1:00 PM.  A short day.

Only collected 200 gallons of sap today: our smallest collection of the season.  We could be coming to the close of the season.  We’ve had 10 collections so far.  Typically we have 9-11 for a season. The next few days turn colder again so there is still the possibility of sap yet.

Into the woods by 8:30 AM to get syrup on the finishing pan.   Done bottling by 11:30 AM.  Then back for tank cleaning at 2:00 PM and to collect at 3:00 PM.  Done collecting by 4:30 PM.  Back to the farmhouse by 5:00 PM.

34 overnight.  Low 40s and partly cloudy today.  Windy late afternoon.  Forecast is 23 overnight and low 40s tomorrow.

Into the woods by 6:45 AM.  R/O running from 7:50 AM to 1:00 PM.  8 batches into milk cans.  Back to the farmhouse by 5:00 PM.  It was a routine day cooking 415 gallons.  We’ve become dependent on the R/O for getting this done and turning this into a routine day.  This is still an amazing development to us with all the past years of “long pleasant hours, few spend in bed” cooking syrup in the woods.

Batches in milk cans

1.   9:00 AM
2. 10:10 AM
3. 11:25 AM
4. 12:35 PM
5.   1:35 PM
6.   2:40 PM
7.   3:35 PM
8.   4:10 PM

25 overnight.  45 and sunny today.  Trees dripped some.  Plan to collect tomorrow.

Into the woods by 8:30 AM to bottle.  First milk can bottled by 11:45 AM.  Then finished and bottled a second milk can.  We still have one milk can of syrup to finish but we have room with two empty milk cans.

At 3:00 PM we went out collecting.  Not collecting yesterday turned out to be the correct decision.  The sap run finished overnight.  When we went out today the trees were not dripping much so we got the whole run.   The new hoses for the new pump arrived.  Just what we needed: flexible and food grade.  The new pump emptied the tank in 8 minutes.  We finished collecting by 4:30 PM.  Four experienced people make short work of it but the new pump also saved us 30 minutes.

Rain overnight.  Mid-30s.  Showers this morning then cloudy most of the day.  Upper 40s.  By 5:00 PM the sun appeared.  The ground is finally starting to get soft: the frost is coming out.

Forecast is 30 overnight and sunny and 50 tomorrow.     Back to the farmhouse by 5:15 PM.

Into the woods by 6:30 AM.  Washed out the pre-filter cloth wraps.  Finished cleaning the syrup pan.  Sitting overnight worked out and made it easy to clean.  The extra R/O hot rinse cycle we did likely wasn’t necessary.  The wash tank water was quite clean.

R/O going by 7:20 AM.  Finished at 12:30 PM.  5 hours for 400 gallons works out to 80 gal/hr.   That’s getting slow.  After the season we want to have the membrane factory washed.

We drew off eight batches into milk cans.  Five batches into the new stainless milk can.  Three into another can.  We now have three full milk cans of syrup waiting for finishing and bottling.

1.    8:50
2.  10:15
3.  11:00
4.  12:05
5.    1:00
6.    1:55
7.    2:55
8.    3:45

In a perfect world we would have collected today.  Some trees dripping well.  And rain is forecast for this evening.  Hope that doesn’t spoil the sap that is in buckets.  But then we couldn’t have finished cooking.

Back to the farmhouse  by 4:15 PM.

Mid 20s overnight.  Sunny and breezy today.  Up to 40 by late in the day, but still took time to warm up.  Trees did drip.  We went out collecting at 3:00.  Picked up 400 gallons.  Starting to see dry taps.   Not surprising since taps have been out for a month already.

Used the new pump to empty the collecting tank.  Its fast.  Once we get the hoses worked out it will be a good upgrade.  New flexible 1” food grade hoses are on order.

Broke the sap hydrometer.  It fell off the hook and hit the concrete floor when we bumped it.  We have a backup, but its older and may  not be as accurate.

Frost still in the ground.  Will we get big runs when the frost comes out?  Or are the trees moving their sap now in smaller runs?

Done collecting by 5:30 PM.  After collecting we started the clean the syrup pan.  Heated water to let it stand overnight.  Hopefully its a quick cleanup in the morning.  Back to the farmhouse by 6:15 PM.  Tomorrow we cook again.

Into the woods by 7:00 AM.  R/O running 7:20 AM to Noon.  7°Brix.  A much better day cooking using a properly calibrated hydrometer.  Nitre did not affect boiling.  Batch off of the evaporator every hour or less.  7 batches total into milk cans.  One milk can filled another with two batches.

28 overnight.  Sunny but windy.  Up to mid 30s but the wind kept it cold.  Trees starting dripping in the afternoon.  Forecast for mid-20s and 43 tomorrow.  Hoping for another sap run.

Back to the farmhouse by 3:00 PM.

15 overnight.  Again.  Sunny and mid to upper 30s but it takes so long to warm.  Checked at 1:00 PM.  Trees starting to drip and ice melting.   But we were not sure we should collect or wait another day.  Looked further in the woods and found some pails mostly full.  Decided to collect at 3:00 PM knowing the sun would help us for two hours yet.

By 3:00 PM the trees were dripping moderately with more ice melted.  Found some full and overflowing pails.  Ended up with 325 gallons of sap.  And that is after dumping ice.  Without dumping ice would have been close to 2 tanks, 450 gallons.  Glad we collected.  Now we have room for another run.

We have to change the hoses on the new pump.  They are too stiff making them hard  to work with.  If the pump gets air is looses flow.  Its hard to keep the stiff hose in the liquid because it wants to curl up and pop out of the liquid sap.

Forecast for 28/29 overnight and low 40s with sun tomorrow.   Into the woods at 2:15.  Back to the farmhouse by 7:15 PM.

15 overnight again.  Sunny and up to 38 by late afternoon.  But it takes so long to warm up when its cold overnight.  Trees started to drip slowly around 2:00 PM.  Still lots of ice in the buckets.  We need some nights with low in the upper 20s to give us a chance.

Into the woods by 3:30 PM to put syrup on the finishing pan.  Working again with   an over dense milk can that needed sap added back to it.  Returned it proper density and finished it.  The filter aid dissolved properly.  Went through the filter press properly.  Ended up with 38 quarts.  Back to the farmhouse by 7:30 PM.

We did get another stainless steel milk can.